en گروه مکانیکی و شکل دادن Mechanical Performance and Formability of Materials Research Paper Research Paper The volatile matter of non-coking coal was used for the reduction of hematite in argon atmosphere at nonisothermal condition. A thermal gravimeter furnace enable to use an 80 mm-height crucible was designed for the experiments to measure the weight changes of about 10 grams samples. A two-layered array of coal and alumina and four-layered array of iron oxide, alumina, coal and alumina was used for the devolatilization and reduction experiments, respectively. The net effect of volatile reduction of Fe 2O3was determined and it was observe that 45% reduction has been achieved. Three distinct regions were recognized on the reduction curve. The reduction of hematite to magnetite could be completely distinguished from the two other regions on the reduction curve. At 600-950°C, the reduction was accelerated. 63% of volatile matter resulted in 25% of total reduction before 600°C while the remaining volatile matter contributed to 75% of the total reduction. From the reduction rate diagram, the stepwise reduction of the iron oxides could be concluded. The partial overlap of the reduction steps were identified through the XRD studies. The starting temperature of magnetite and wüstite reduction were determined at about 585°C and at 810°C, respectively. volatile matter, iron oxide, non-coking coal,non isotherm, reduction 66 74 http://ijmse.iust.ac.ir/browse.php?a_code=A-10-127-96&slc_lang=en&sid=1 M. H. Hemmati 180031947532846003327 180031947532846003327 No Department of Metallurgical Engineering, Iron and Steel Research Center, Ferdowsi University of Mashhad, Iran. J. Vahdati Khaki vahdati@um.ac.ir 180031947532846003328 180031947532846003328 Yes Department of Metallurgical Engineering, Iron and Steel Research Center, Ferdowsi University of Mashhad, Iran. A. Zabett 180031947532846003329 180031947532846003329 No Department of Metallurgical Engineering, Ferdowsi University of Mashhad, Iran.